#CLUB CAR 8 VOLT GOLF CART BATTERIES HOW TO#
How To Test Golf Cart Batteries With Load Testing
#CLUB CAR 8 VOLT GOLF CART BATTERIES FULL#
A typical 6-volt lead-acid battery with a full charge – battery caps are distributed one per 2.1v cell. The automatic charger has no way to know this and will continue to charge the battery bank trying to get to a full charge – meaning it will take a longer charge time for the batteries than normal. As the battery bank ages, it will not hold a charge as well as it used to. A deep cycle battery charge time takes twice as long to charge your batteries as it did when you first had a battery bank installed.On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the speed controller not engaging, a faulty maintenance switch, or when the voltage falls below a preset value.Use a volt meter to measure each battery individually to isolate individual battery health. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue. A “Shutter” feels like you are running across a corduroy road or someone is tapping the brake rapidly.You may notice the battery power and range decreasing over time. The range should be about 2 rounds of golf after charging back to the advertised voltage using a full trickle charge cycle.Symptoms of a failing battery or batteries could include the following: Be sure to check the charger while you are testing the golf cart battery or batteries.Ĭheck Out This Article – How To Test Golf Cart Batteries Automatic Charger How Do You Tell If Your Golf Cart Battery Bank Is Bad? It is common to assume the battery is the problem, but there is a chance that the golf cart battery chargers have a problem. Details on this product and battery reconditioning can be found at Was It The Batteries Or The Battery Charger At Fault? The De-Sulfater can restore and preserve the plates in new and used batteries and keep them in peak condition. Thermoil has a product (De-Mister) that, when added, floats on the surface of the electrolyte fluid and reduces water consumption and corrosion. It only takes one slip to cause serious injury.Ī battery recondition can also be tried with Thermoil. Safety GearĪlso, be aware of using eye protection, gloves, and an apron when working around acid batteries, especially ones with a full charge. After the battery is charged, the once distilled water is now sulphuric battery acid. Impurities in the water contribute to the deposits that form on the inner components of the battery. Note: Never use tap water.only distilled water should be used in refilling a battery. If your battery is still not holding the full charge, it is probably beyond repair and a battery replacement is recommended.
It may take several charges/discharge cycles before you can tell if there is a difference. Charge the batteries overnight again to a full charge cycle and run step 6 again.
0 kommentar(er)
